乐泰loctite cat23lv cl资料MSDS
Safety Data Sheet
Revision Number: 005.0 Issue date: 04/21/2017
1. PRODUCT AND COMPANY IDENTIFICATION
Product name: Catalyst 23LV(226.8g), IDH number: 1420847
Product type: Catalyst Item number: NEW
Restriction of Use: None identified Region: Canada
Company address: Contact information:
Henkel Electronic Materials LLC Telephone: +1 (888) 943-6535
14000 Jamboree Road MEDICAL EMERGENCY Phone: Poison Control Center
Irvine, CA 92606 1-877-671-4608 (toll free) or 1-303-592-1711
TRANSPORT EMERGENCY Phone: CHEMTREC
1-800-424-9300 (toll free) or 1-703-527-3887
Internet: www.henkel.com/electronics
2. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
DANGER: HARMFUL IF SWALLOWED.
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
MAY CAUSE AN ALLERGIC SKIN REACTION.
HAZARD CLASS HAZARD CATEGORYACUTE TOXICITY ORAL 4
SKIN CORROSION 1
SERIOUS EYE DAMAGE 1
SKIN SENSITIZATION 1
PICTOGRAM(S)
Precautionary Statements
Prevention: Avoid breathing vapors, mist, or spray. Wash affected area thoroughly after handling. Do not
eat, drink or smoke when using this product. Contaminated work clothing should not be allowed
out of the workplace. Wear protective gloves, clothing, eye and face protection.
Response: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF SWALLOWED: Rinse mouth. Do
NOT induce vomiting. If on skin (or hair): Take off immediately all contaminated clothing. IF
INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing.
Immediately call a POISON CENTER or physician. IF IN EYES: Rinse cautiously with water for
several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If skin
irritation or rash occurs: Get medical attention. Wash contaminated clothing before reuse.
Storage: Store locked up.
Disposal: Dispose of contents and/or container according to Federal, State/Provincial and local
governmental regulations.
Classification complies with Canadian Hazardous Products Regulations (WHMIS 2015) and is consistent with the provision of the UnitedNations Globally Harmonized System of Classification and Labeling of Chemicals (GHS).
See Section 11 for additional toxicological information.
IDH number: 1420847 Product name: Catalyst 23LV(226.8g),
Page 1 of 5
3. COMPOSITION / INFORMATION ON INGREDIENTS
Hazardous Component(s) CAS Number Weight %*
Polypropylene glycol diamine (MW=230) 9046-10-0 50 - 60
3,3'-Oxybis(ethyleneoxy)bis(propylamine) 4246-51-9 40 - 50
* Exact percentages may vary or are trade secret. Concentration range is provided to assist users in providing appropriate protections.
4. FIRST AID MEASURES
Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give oxygen. Get medical attention.
Skin contact: Immediately flush skin with plenty of water (using soap, if available). Remove
contaminated clothing and footwear. Get medical attention. Wash clothing
before reuse.
Eye contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes. Get medical attention.
Ingestion: Do not induce vomiting or give anything by mouth because this material can
enter the lungs and cause severe lung damage. Never give anything by mouth
to an unconscious person. Get medical attention.
Symptoms: See Section 11.
5. FIRE FIGHTING MEASURES
Extinguishing media: Water spray (fog), foam, dry chemical or carbon dioxide.
Special firefighting procedures: Wear self-contained breathing apparatus and full protective clothing, such as
turn-out gear. In case of fire, keep containers cool with water spray.
Unusual fire or explosion hazards: Closed containers may rupture (due to build up of pressure) when exposed to
extreme heat.
Hazardous combustion products: Oxides of carbon, oxides of nitrogen, irritating organic vapors. Ammonia. Toxic
fumes.
6. ACCIDENTAL RELEASE MEASURES
Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotectedpersonnel.
Environmental precautions: Do not allow product to enter sewer or waterways.
Clean-up methods: Remove all sources of ignition. Ensure adequate ventilation. Isolate area.
Keep unnecessary personnel away. Soak up with inert absorbent material
(e.g. sand, silica gel, acid binder, universal binder, sawdust). Store in a closed
container until ready for disposal. Refer to Section 8 "Exposure Controls /
Personal Protection" prior to clean up.
乐泰loctite cat23lv cl资料MSDS：
本文来自：汉高乐泰胶水（中国）有限公司 Henkel Loctite官网 www.loctite.net/c1225.html
IDH number: 1420847 Product name: Catalyst 23LV(226.8g),
Page 2 of 5
7. HANDLING AND STORAGE
Handling: Use only with adequate ventilation. Prevent contact with eyes, skin and
clothing. Do not breathe vapor and mist. Wash thoroughly after handling.
Refer to Section 8.
Storage: For safe storage, store at or below 25 °C (77°F)
Keep in a cool, well ventilated area away from heat, sparks and open flame.
Keep container tightly closed until ready for use.
For information on product shelf life, please review labels on container or check the Technical Data Sheet.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposurecontrols and protective equipment for each task performed.
Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHERPolypropylene glycol diamine (MW=230) None None None None3,3'-Oxybis(ethyleneoxy)bis(propylamine) None None None None
Engineering controls: Provide adequate local exhaust ventilation to maintain worker exposure below
exposure limits.
Respiratory protection: Use a NIOSH approved air-purifying respirator if the potential to exceed
established exposure limits exists.
Eye/face protection: Safety goggles or safety glasses with side shields. Full face protection should
be used if the potential for splashing or spraying of product exists. Safety
showers and eye wash stations should be available.
Skin protection: Use chemical resistant, impermeable clothing including gloves and either an
apron or body suit to prevent skin contact. Cover as much of the exposed skin
area as possible with appropriate clothing.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid
Color: Amber
Odor: Amine
Odor threshold: Not available.
pH: > 11.7
Vapor pressure: < 0.01 mbar (25 °C (77°F))
Boiling point/range: > 160 °C (> 320°F)
Melting point/ range: Not applicable
Specific gravity: 1.01
Vapor density: Not applicable
Flash point: > 93 °C (> 199.4 °F) Pensky Martens closed cup
Flammable/Explosive limits - lower: Not available.
Flammable/Explosive limits - upper: Not available.
Autoignition temperature: Not available.
Flammability: Not applicable
Evaporation rate: Not applicable
Solubility in water: Soluble
Partition coefficient (n-octanol/water): Not determined
VOC content: 250 g/l
Viscosity: Not available.
Decomposition temperature: Not available.
IDH number: 1420847 Product name: Catalyst 23LV(226.8g),
Page 3 of 5
10. STABILITY AND REACTIVITY
Stability: Stable under normal conditions of storage and use.
Hazardous reactions: Will not occur.
Hazardous decomposition Oxides of carbon. Oxides of nitrogen. Toxic fumes. Ammonia.
products:
Incompatible materials: Strong acids and oxidizing agents. Sodium hypochlorite. Reaction with peroxides may result in
violent decomposition of peroxide possibly creating an explosion. This product slowly corrodes
copper, aluminum, zinc and galvanized surfaces.
Reactivity: Not available.
Conditions to avoid: High temperatures. Store away from incompatible materials. Heat, flames, sparks and other
sources of ignition.
11. TOXICOLOGICAL INFORMATION
Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion
Potential Health Effects/Symptoms
Inhalation: May cause respiratory tract irritation.
Skin contact: Causes skin burns. May cause allergic skin reaction.
Eye contact: Causes serious eye damage. Burns of the eye may cause blindness.
Ingestion: Harmful if swallowed. Irritation and corrosive action can occur in the mouth, stomach tissue and
digestive tract if swallowed.
Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health EffectsPolypropylene glycol diamine (MW=230) None Corrosive, Irritant3,3'-Oxybis(ethyleneoxy)bis(propylamine) None Corrosive
Hazardous Component(s) NTP Carcinogen IARC Carcinogen OSHA Carcinogen
(Specifically Regulated)Polypropylene glycol diamine (MW=230) No No No3,3'-Oxybis(ethyleneoxy)bis(propylamine) No No No
12. ECOLOGICAL INFORMATION
Ecological information: Not available.
IDH number: 1420847 Product name: Catalyst 23LV(226.8g),
Page 4 of 5
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Follow all local, state, federal and provincial regulations for disposal.
14. TRANSPORT INFORMATION
The transport information provided in this section only applies to the material/formulation itself, and is not specific to any
package/configuration.
Canada Transportation of Dangerous Goods - Ground
Proper shipping name: POLYAMINES, LIQUID, CORROSIVE, N.O.S. (Polyoxy propylene diamine, 3,3'-
oxybis(ethyleneoxy)bis(propylamine))
Hazard class or division: 8
Identification number: UN 2735
Packing group: II
International Air Transportation (ICAO/IATA)
Proper shipping name: Polyamines, liquid, corrosive, n.o.s. (Polyoxy propylene diamine, 3,3'-
oxybis(ethyleneoxy)bis(propylamine))
Hazard class or division: 8
Identification number: UN 2735
Packing group: II
Water Transportation (IMO/IMDG)
Proper shipping name: POLYAMINES, LIQUID, CORROSIVE, N.O.S. (Polyoxy propylene diamine, 3,3'-
oxybis(ethyleneoxy)bis(propylamine))
Hazard class or division: 8
Identification number: UN 2735
Packing group: II
15. REGULATORY INFORMATION
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic
Substances List.
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act
Inventory.
16. OTHER INFORMATION
This safety data sheet contains changes from the previous version in sections: New Safety Data Sheet format. 11
Prepared by: Debbie Friday, Regulatory Affairs Specialist
Issue date: 04/21/2017
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel
Corporation and its affiliates (“Henkel”) does not assume responsibility for any results obtained by persons over whose methods
Henkel has no control. It is the user’s responsibility to determine the suitability of Henkel’s products or any production methods
mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and
persons against any hazards that may be involved in the handling and use of any Henkel’s products. In light of the foregoing,
Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular
purpose, arising from sale or use of Henkel’s products. Henkel further disclaims any liability for consequential or incidental damages
of any kind, including lost profits.
IDH number: 1420847 Product name: Catalyst 23LV(226.8g),
Page 5 of 5
